Step 1

Choose your pork. A pork shoulder is great, but a pork butt (sometimes called Boston Butt) is better. They are similar cuts of meat and have all the fat and connective tissues we need to break down into a tender and juicy pulled pork (Butts have just a little more). Use a bone-in butt or shoulder if you can find it, but boneless if fine too. Choose one that is well marbled with white fat.

Step 2

Marinate with spice rub. In a small bowl, combine 1 tablespoon kosher salt, 2 teaspoons black pepper, 1 tablespoon paprika, 2 teaspoons garlic powder, 2 teaspoons onion powder, 1 teaspoon chili powder, 1 teaspoon cayenne pepper, 2 teaspoon cumin, 1 teaspoon dry mustard powder, and 1/3 cup packed brown sugar. Measure out 3 tablespoons of this mixture and set aside in a small ziplock or covered bowl; you will need it later.

Step 3

If you would like to speed up the cooking process, use a sharp knife to cut the pork in half. This will increase the surface area of meat that you are able to brown on the stove (increasing flavor) and shorten the crock pot time to about 6-7 hours. (It's totally okay to leave the pork butt whole, it will cook in about 8-10 hours.)

Step 4

Use paper towels to dry off the pork as best you can. Massage 3 tablespoons olive oil into the meat, making sure it's well distributed. Drizzle 1 teaspoon liquid smoke over the pork and massage it in. This step is optional but I like the smoky flavor it adds, which helps make up for the fact that we aren't cooking this pork in a smoker or on the grill.

Step 5

Use your hands to rub the spices (all but 3 tablespoons) into the meat, getting every nook and cranny and under every flap. Place in a large ziplock bag and seal (I love these 2 gallon bags).

Step 6

Marinate in the fridge for at least 6 hours, or up to 48 hours.

Step 7

Remove the pork from the ziplock and pat dry if it is wet. Rub the remaining 3 tablespoons of the spice rub mixture into the pork.

Step 8

Set a large dry skillet on your stove over medium high heat. Let the skillet preheat for at least 3 minutes on medium high. Add 2 tablespoons vegetable oil and swirl to coat the pan. The oil should shimmer immediately.

Step 9

Add the pork and sear for about 2 minutes until well browned. Use tongs to flip the pork and sear the other side until browned. Flip again onto its side, until all the outside of the pork is seared. Add more oil as necessary. Repeat with the other piece, if you split it in half.

Step 10

Place the seared pork into your dry crock pot. Cover with the lid and cook on low heat for 6-8 hours if you split it in half, and about 8-10 hours if you left it whole.

Step 11

Do not overcook your pork. You only want the temperature of the meat to reach about 200 degrees, so start checking it with a meat thermometer at the lowest recommended cook time. It's tempting to set it and forget it, but your pork will taste dried out and stringy if you leave it in too long. Rely on your meat thermometer. You can remove it from the slow cooker anywhere between 195 and 200 degrees F, since the meat will continue rising in temperature even after you take it out of the slow cooker.

Step 12

Remove the pork from the slow cooker and let rest on a cutting board for about 5 minutes, tented with foil.

Step 13

Shred the pork using two forks. It should be just completely falling apart. Remove any gristle, but do not discard all the fat! Shred it up and toss it in with the meat. Fat=flavor, and that slow cooked fat is part of what makes pulled pork so amazing. (You don't throw out the strips of fat on bacon, do you? I think not. Show your pork some respect.)

Step 14

Add the shredded pork back into the crock pot (or whatever you plan to serve in) and toss with the cooking liquid.

Step 15

You can stir about 1 to 2 cups homemade or store bought BBQ sauce into the pulled pork, or serve it with BBQ sauce as an optional topping. Serve warm on sandwiches (more instructions on that below), top a salad, use for meal prep, whatever your little heart desires.

Step 16

Cut your pork butt or shoulder into 3 equal pieces. This is to speed up the cooking process and to increase the amount of edges that will get browned in the oven. Hello flavor!

Step 17

Follow the same instructions above for preparing your pork: pat dry, rub with 3 tablespoons olive oil and 1 teaspoon liquid smoke (optional), then rub with all but 3 tablespoons of the spice rub. Place in a large ziplock and marinate for 6 to 48 hours.

Step 18

Remove the pork from the fridge and let sit at room temperature for about an hour. This ensures more even cooking in the oven. Nobody wants a dry outer edge.

Step 19

Preheat your oven to 425 degrees F. Let it heat up for at least 20 minutes.

Step 20

Place an oven-safe wire cooling rack over a rimmed baking sheet. Spray with nonstick spray. Add 1 and 1/2 cups water to the bottom of the pan, to provide a humid environment while the pork is cooking.

Step 21

Remove the pork from the ziplock and rub each piece with the remaining 3 tablespoons spice rub. Place the pork on the cooling rack, making sure the pieces are not touching each other. Fat caps should be on top, if you can.

Step 22

Roast in the oven for 30 minutes at 425 degrees. This initial blast of heat is to help sear the edges of the pork. After 30 minutes, lower the oven temperature to 300 degrees. Open the oven door for 30-60 seconds to cool the oven down a bit. Close the door.

Step 23

Roast at 300 degrees for another 3-5 hours, depending on how large the pieces are. Add more water to the bottom of the pan as necessary. Rely on your meat thermometer to test for doneness. Take the pork out of the oven when a meat thermometer reads 195 to 200 degrees F. Do not let the meat go above 200 degrees, as the temperature will keep rising a few degrees after you take it out of the oven.

Step 24

Remove the pork from the oven and let rest for about 15-20 minutes, tented with foil. Transfer the pork to a cutting board.

Step 25

Shred the pork using two forks. It should be just completely falling apart. Remove any gristle, but do not discard all the fat! Shred it up and toss it in with the meat. Fat=flavor.

Step 26

Make a sandwich: To make the best pulled pork sandwich of your life, butter both sides of a brioche bun. Heat another tablespoon of butter in a pan over medium heat on the stove. Toast the buns for 2-4 minutes, until lightly golden.

Step 27

Add shredded pork to your bun. Top with more BBQ sauce, if desired. Top with an unreasonable amount of lemony herb coleslaw, if you're like me. Smash with the top of your toasty brioche bun and devour messily.

Step 28

Store leftovers in an airtight container in the fridge. It will keep for 4-5 days in the fridge.

Step 29

Pulled pork freezes very well. Seal in a ziplock bag (with or without BBQ sauce mixed in). It will freeze for up to 4-6 months. Let thaw in the fridge overnight. Heat leftovers in the microwave, or place in a tin foil covered pan, sprinkle with water, and bake in an oven set to 300 for about 20-40 minutes, depending on how much there is.