Step 1

Gather all the instructions.

Step 2

Roll up the pork belly, making sure one or both ends should have the “bacon” like appearance, showing the varying layers of meat and fat. If your slab comes with the skin (rind), it should be facing out. My block does not come with it. See Notes if you want to remove it.

Step 3

Run some butcher twine under the far end of the log. Tie a double knot to secure the pork tightly. Make sure you leave about 3 inches (7.5 cm) twine at the end.

Step 4

Wrap around the pork belly 2-3 times around the same area to secure the end. Then pull the twine to the other end of the pork belly. Wrap around 2-3 times at the end area to secure before working toward the middle. Each wrap should be a ⅓ inch (1 cm) in between.

Step 5

Continue wrapping around the pork belly toward the end (where you started). Make sure it’s tightly wrapped as much as possible.

Step 6

Once you reach the end, run the butcher twine under some wraps to hook and go back to the starting point. Find the 3-inch (7.5 cm) twine you leave behind.

Step 7

Tie a double knot with the long twine and the 3-inch (7.5 cm) twine.

Step 8

Cut off the green part of long green onion and slice the ginger (I use organic ginger; rinse and use the skin).

Step 9

Heat the oil in a cast iron skillet (or regular frying pan) over high heat. Add the rolled pork belly in the pan.

Step 10

Sear the pork belly one side at a time, rotating to make sure all sides are nicely seared.

Step 11

It’ll take about 10-15 minutes all together.

Step 12

While searing, put all the ingredients for seasonings in a heavy-bottom pot (or regular pot) that fits the Chashu.

Step 13

Transfer the seared Chashu into the Dutch oven.

Step 14

Bring the liquid to a boil.

Step 15

Once boiling, skim off the foam and scum. Then turn the heat to low/simmer.

Step 16

Put an Otoshibuta (drop lid) on top to press the ingredient down. You do not need to use the regular lid and limit the evaporation by just Otoshibuta. If you don’t have an Otoshibuta, you can make it with aluminum foil (here’s how to make Otoshibuta).

Step 17

Simmer on low heat, and covered with Otoshibuta at all times for the next 2 hours, rotating Chashu every 30 minutes.

Step 18

The sauce has been reduced. After 2 hours, turn off the heat to let cool a little bit.

Step 19

Once the meat is slightly cooled, transfer to a container or plastic Food Saver bag. Strain the leftover cooking liquid over a fine-mesh strainer. The liquid is roughly 2 ½ cup.

Step 20

Add ½ cup of the cooking liquid into the bag.

Step 21

Seal the bag with Food Saver. TIP: Fold a piece of paper towel to plug the entry of the Food Saver bag. This paper towel will absorb all the moisture when you seal.

Step 22

I also made a quick Ramen Egg (Ajitsuke Tamago) with the leftover liquid. You make soft boiled eggs and add ½ cup of cooking liquid in the bag. Cover the cooking liquid and store Chashu, Ramen Egg, and the cooking liquid in the refrigerator.

Step 23

Open the bag of Chashu.

Step 24

Cut the twine with kitchen shears and remove them completely.

Step 25

Slice the Chashu into ¼ inch pieces (Keep the edge for Chashu Fried Rice!).

Step 26

Place the Chashu slices on a ceramic plate and use a propane torch or broiler to sear the Chashu slices to enhance the flavor. Then enjoy them immediately or serve on your ramen.

Step 27

Scoop up the solidified fat from the cooking sauce.

Step 28

Prepare a mason jar or container and strain the sauce over a fine-mesh sieve to make sure the solidified fat is left behind. The sauce will last for a month in the refrigerator. I use it for drizzling over the Chashu and making stir-fries, marinade, and ramen eggs.

Step 29

You can store the Chashu in the refrigerator up to 7 days and 1 month in the freezer. I usually divide the Rolled Chashu into thirds and freeze 2 portions separately (for Ramen right away, and Chashu Fried Rice and Chashu Don for later). Ramen Eggs should be consumed in 3-4 days if they are soft-boiled eggs and 7 days if hard-boiled eggs. The eggs get salty as you keep in the marinade, so remove from the sauce when they have the right taste.

Step 30

Gather all the ingredients. For small blocks of pork belly, you don't need to roll them up before cooking and simmering time is just 1 hour (instead of 2 hours).

Step 31

Heat the oil in a cast iron skillet (or regular frying pan) over high heat. Sear the fat side down first, then flip over to sear all sides, which will take about 10 minutes.

Step 32

While searing, put all the ingredients for seasonings in a heavy-bottom pot (or regular pot) that fits the Chashu. Add the Chashu and bring it to a boil, skimming the scum and foam. Then turn the heat to low/simmer.

Step 33

Put an Otoshibuta (drop lid) on top to press the ingredient down and limit the evaporation. If you don’t have an Otoshibuta, you can make it with aluminum foil. (here’s how to make Otoshibuta). Simmer on low heat for next one hour, rotating Chashu every 15 minutes (keep Otoshibuta on all times!).

Step 34

After one hour, there is ½ inch liquid left in the pot. Now you have 2 options. Option 1: If you're serving right away, remove the Otoshibuta and further cook down the sauce on low heat until the sauce gets thicken and see the bottom of the pot when you draw a line with a spatula. Option 2 (recommended): Transfer the Chashu to a container or a bag with a little bit of cooking sauce and refrigerate overnight. Strain the leftover cooking sauce and refrigerate.

Step 35

To serve, slice the Chashu into ¼ inch pieces. You can use a propane torch or broiler to sear the Chashu slices to enhance the flavor. If you kept the Chashu overnight and don't want to sear the Chashu, you can reheat it by soaking in the hot cooking sauce.